Product ID:REVEAL, 0567
MSDS Date:06/25/1999
FSC:NIIN:Submitter:D RV
Status Code:A
MSDS Number: CLLGP

NATIONAL CHEMSEARCH DIV OF NCH CORP

2727 CHEMSEARCH BLVD
IRVING, TX 75015-5000
US

Emergency Phone: 972 438-1381

Info Phone: 972-438-1381

Preparer: M. DICKSON/CHEMIST

Cage: DO481

NATIONAL CHEMSEARCH DIV OF NCH CORP

152170 IRVING, TX 75015-5000 US

Telephone: 972-438-1381

Cage: DO481

SODIUM METASILICATE

CAS: 6834-92-0

RTECS: VV9275000

OSHA PEL 2 MG/M3

ETHYLENE GLYCOL MONOBUTYL ETHER

CAS: 111-76-2

RTECS: KJ8575000

OSHA PEL 25 PPM

ACGIH TLV: 121 MG/M3;25 PPM

NONYL PHENOL POLYETHYLENE GLYCOL ETHER

CAS: 127087-87-0

MONOETHANOLAMINE

CAS: 141-43-5

RTECS: KJ5775000

OSHA PEL 6 MG/M3;3 PPM

ACGIH TLV: 7.5 MG/M3;3 PPM

SAFROLE

CAS: 94-59-7

RTECS: CY2800000

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

LD50 LC50 Mixture:MONOETHAOLAMINE ORAL-RAT LD50:2100 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE (SHORT TERM EXPOSURE): EYE:
CAUSES SEVERE IRRITATION SEEN AS TEARING, REDNESS, AND BURNING
SENSATION. SKIN: CAUSES SEVERE IRRITATION SEEN AS REDNESS, ITCHING
AND BURNING SENSATION. INHALATION: C AUSES IRRITATION OF THE
RESPIRATORY TRACT SEEN AS COUGHING AND SNEEZING. INGESTION: CAUSES
GASTROINTESTINAL IRRITATION WITH POSSIBLE NAUSEA, VOMITING AND
DIARRHEA. MAY CAUSE CENTRAL NERVOUS SYSTEM EFF ECTS SUCH AS
INCOORDINATION, DROWSINESS, DIZZINESS, MENTAL CONFUSION, SLURRED
SPEECH, AND STUPOR. TARGET ORGANS: LIVER, KIDNEY, RESPIRATORY
SYSTEM, BLOOD, SPLEEN, TESTIS, AND GASTROINTESTINAL TRACT.C
HRONIC:SEE SUPP DATA
Explanation of Carcinogenicity:PRODUCT CONTAINS CHEMICALS LISTED AS
CARCINOGEN OR POTENTIAL CARCINOGEN.
Effects of Overexposure:CHRONIC (LONG TERM EXPOSURE): LONGTERM
INHALATION RESULTING FROM AIRBORNE CONCENTRATIONS OF MIST OR SPRAY
MAY CAUSE DAMAGE TO UPPER RESPIRATORY TRACT. PROLONGED/REPEATED
SKIN CONTACT: RESULT IN SUPERF ICIAL DESTRUCTIONS OF SKIN TISSUE
AND DERMATITIS. CHRONIC EYE EXPOSURE CAN LEAD TO DESTRUCTION OF EYE
TISSUE OR BLINDNESS. REPEATED OR PROLONGED SKIN CONTACT MAY BE
HARMFUL. AS INGREDIENT IN THIS PROD UCT CAN BE ABSORBED THROUGH
SKIN, KIDNEY AND LIVER DAMAGE MAY OCCUR.SEE SUPPLEMENTAL DATA
Medical Cond Aggravated by Exposure:PRE-EXISTING LIVER, KIDNEY,
RESPIRATORY AND SKIN DISEASES.

First Aid:INHALATION: REMOVE FROM AREA TO FRESH AIR.SEEK MEDICAL
ATTENTION IF RESPIRATORY IRRITATION DEVELOPS OR BREATHING
DIFFICULT.EYES: IMMEDIATELY RINSE EYES WITH WATER.REMOVE ANY
CONTACT LENSES AND FLUSHIN G AT LEAST 15 MINUTES. HOLD EYELIDS
APART TO ENSURE RINSING OF ENTIRE SURFACE OF EYES AND LIDS WITH
WATER. GET IMMEDIATE MEDICAL ATTN.SKIN: WASH AFFECTED AREAS WITH
LARGE AMOUNTS OF SOAP AND WATER 15 MINUTES. REMOVE AND WASH
CONTAMINATED CLOTHING, CLEAN SHOES BEFORE REUSE. GET IMMEDIATE
MEDICAL ATTENTION. INGESTION: GIVE 3 TO 4 GLASSES OF WATER, BUT DO
NOT INDUCE VOMITING. IF VOMITING OCCURS, GI VE FLUIDS AGAIN. SEEK
MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:NON-FLAMMABLE
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, AND/OR WATER
SPRAY.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR A SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY TO PREVENT BURSTING. CHOOSE
EXTINGUISHING MEDIA BASED ON NATURE OF THE FIRE.
Unusual Fire/Explosion Hazard:OXIDES OF NITROGEN, OXIDES OF CARBON AND
AMMONIA.

Spill Release Procedures:DIKE AND CONTAIN SPILL IF SAFE TO DO SO.
ABSORB WITH AN INERT MATERIAL AND TRANSFER ALL MATERIAL INTO A
PROPERLY LABELED CONTAINER FOR DISPOSAL. WEAR APPROPRIATE
PROTECTIVE CLOTHING. USE CARE AS SPILL S MAY BE SLIPPERY.
Neutralizing Agent:USE DILUTE MINERAL ACIDS. ADD CAUTIOUSLY WHILE
MIXING. WEAR APPROPRIATE PROTECTIVE CLOTHING.

Handling and Storage Precautions:ALWAYS STORE MATERIAL IN ITS ORIGINAL
CONTAINER. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE. WASH
AFTER HANDLING. WEAR PROTECTIVE CLOTHING WHEN HANDLING. STORAGE
TEMPERATURE: INDOORS/OUTDOORS MINM UM TEMPERATURE: 32F MAXIMUM
TEMPERATURE: 120F.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ THE ENTIRE LABEL
BEFORE USING THE PRODUCT. FOLLOW THE LABEL DIRECTIONS.

Respiratory Protection:A NIOSH/MSHA APPROVED RESPIRATOR IN POORLY
VENTILATED AREAS AND/OR FOR EXPOSURE ABOVE THE ACGIH TLV OR OSHA
PEL OR WHERE MISTING EXISTS.
Ventilation:GENERAL MECHANICAL VENTILATION IS NORMALLY ADEQUATE.
Protective Gloves:NEOPRENE RUBBER OR POLYVINYL ALCOHOL GLOVES SHOULD BE
WORN.
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS SHOULD BE WORN WHEN
HANDLING.
Other Protective Equipment:WEAR A NEOPRENE OR POLYVINYL ALCOHOL APRON
AND BOOTS.
Supplemental Safety and Health
CHRONIC:LONG TERM INHALATION OF MIST OR SPRAY MAY CAUSE DAMAGE TO UPPER
RESPIRATORY TRACT. PROLONGED OR REPEATED SKIN CONTACT MAY RESULT IN
SUPERFICIAL DESTRUCTION OF SKIN TISSUE AND DERMATITS.CHRONIC EYE
EXPOSURE CAN LEAD TO DISTRUCTION OF EYE TISSUE OR
BLINDNESS.REPEATED OR PROLONGED SKIN CONTACT CAN BE HARMFUL.

HCC:B3
Boiling Pt:=98.9C, 210.F
Vapor Pres:18 (MM HG)
Vapor Density:0.6
Spec Gravity:1.010
pH:11.8
Viscosity:NON-VISCOUS
Evaporation Rate & Reference:0.10
Solubility in Water:COMPLETE
Appearance and Odor:BLUE, TRANSPARENT, AMINE SOLUTION. ODOR: SASAFRASS.
Percent Volatiles by Volume:95

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONG BASES, ALUMINUM, COPPER,
TIN, LEAD, ALDEHYDES, KETONES, AND ORGANIC HALIDES.
Stability Condition to Avoid:STABLE
Hazardous Decomposition Products:OXIDES OF CARBON, NITROGEN AND SILICA
AND UNIDENTIFIED ORGANIC COMPOUNDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, AND LOCAL REGULATIONS.

Toxicological Information:SODIUM METASILICATE SKN-HMN:250 MG/24
SEV,ORL-PIG LDLO:250 MG/KG,ORAL RAT LD50:1280 MG/KG. ETHYLENE
GLYCOL. MOMOBUTYL ETHER ORL-RAT LD50: 470 MG/KG,SKN-RBT:200 MG/KG,
LC50:450 PPM/4H. MONOETHANOLAMIN E ORL-RAT LD50: 2100
MG/KG,SKN-RBT:1000MG/KG. NONYL PHENOL POLYETHYLENE GLYCOL ETHER
ORL-RAT LD50: 1310 MG/KG, SKN-RBT LD50:2000 MG/KG.INHALATION
EXPOSURE TO 2-BUTOXYETHANOL PRODUCED SOME EVIDENCE OF CANCER IN
MICE IN LONG TERM BIOASSY.PRODUCT CONTAINS LESS THAN 0.2% SAFROL
WHICH HAS BEEN FOUND A CARCINOGEN IN ANIMALS. SAFEROL HAS BEEN
PROHIBITED FOR USE IN HUMAN FOOD BY FDA, ITS EFFECT ON HUMANS HAS
IS UNKOWN.SKN-RBT:500 MG/24HR.

Federal Regulatory Information:GLYCOL ETHER, UPPER % LIMIT:15, SAFROL
(94-59-7) UPPER % LIMIT:0.2. CALIFORNIA PROPOSITION 65, WARNING:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL (S) THAT IS KNOWN TO
THE STATE OF CALIFORNIS TO CAU SE CANCER OR BIRTH DEFECTS OR OTHER
PRODUCTIVE HARM. THIS PRODUCT CONTAINS: DIOXANE, FORMALDEHYDE,
ACETALDEHYDE AND ETHYLENE OXIDE AS TRACE CONTAMINANTS.
State Regulatory Information:GLYCOL ETHER, UPPER % LIMIT:15, SAFROL
(94-59-7) UPPER % LIMIT:0.2. CALIFORNIA PROPOSITION 65, WARNING:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL (S) THAT IS KNOWN TO
THE STATE OF CALIFORNIS TO CAU SE CANCER OR BIRTH DEFECTS OR OTHER
PRODUCTIVE HARM. THIS PRODUCT CONTAINS: DIOXANE, FORMALDEHYDE,
ACETALDEHYDE AND ETHYLENE OXIDE AS TRACE CONTAMINANTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.